MTD 550 Thru 570 Manual del operador descargar pdf

Operator's Manual

Log Splitter

Model Series

550 through 570

IMPORTANT: Read safety rules and instructions carefully before operating equipment.

Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-

covered, brush-covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting

applicable local or state laws (if any). If a spark arrester is used, it should be maintained in effective working order by the operator.

In the State of California the above is required by law (Section 4442 of the California Public Resources Code). Other states may have

similar laws. Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized

service dealer or contact the service department, P.O. Box 368022 Cleveland, Ohio 44136-9722.

MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019

PRINTED IN U.S.A.

FORM NO. 770-10529D

(5/2004)

1 2 3 4 5 6 ... 15 16

Indice de contenidos

Pagina 1 - Operator's Manual

Operator's ManualLog SplitterModel Series550 through 570IMPORTANT: Read safety rules and instructions carefully before operating equipment.Warnin

Pagina 2 - CUSTOMERSUPPORT

b. Ifcouplerhitchistoo looseonball:Turnadjustmentnutoneturnclockwise.Connectthesafetychainstothetowingvehicle.Pluginthetaillights,if soequipped,tothet

Pagina 3

HydraulicFluid• Check the hydraulic fluid level in the log splitterreservoir tank before each use.• Maintain fluid level within the range specified on

Pagina 4 - YourResponsibility

SECTION7: STORINGYOURLOGSPLITTERPrepare your log splitter for storage at the end of theseason or if the log splitter will not be used for 30 daysor mo

Pagina 5 - ConnectingCylindertoBeam

HydraulicTroubleshootingProblemCylinder rod will not moveSlow cylinder shaft speedwhile extending andretracting.Leaking cylinderEngine runs but wood w

Pagina 6 - PreparingtheLog Splitter

SECTION9: PARTSLISTFORMODELSERIES550 THROUGH57056lO133916184526 29\28 \ 5 31\CI70A_ 68_ |853 67 _ 72\\\54606574\75 \For TaillightGround Wire82\\81 \\7

Pagina 7 - SECTION3: KNOWYOURLOGSPLITTER

ModelSeries550through570Ref.Part No.No.1. 718-07692. 727-06343. 710-10184. 737-01925. 781-0526t6. 737-01537. 718-04818. 781-0538t9. 710-180610. 719-05

Pagina 8 - Usingthe LogSplitter

MANUFACTURER'S LIMITED WARRANTY FOR:The limited warranty set forth below is given by MTD LLC withrespect to new merchandise purchased and used in

Pagina 9 - TransportingtheLogSplitter

TABLEOFCONTENTSContentImportant Safe Operation PracticesAssembling Your Log SplitterKnow Your Log SplitterOperating Your Log SplitterAdjusting Your Lo

Pagina 10 - GibAdjustment

SECTION1: IMPORTANTSAFEOPERATIONPRACTICES_ ARNING" This symbol points out important safety instructions which, if not followed, could endangerthe

Pagina 11 - FlexiblePumpCoupler

h. Ifgasolineisspilled,wipeitofftheengineandequipment,movemachinetoanotherarea.Wait5minutesbeforestartingtheengine.i. Neverstorethemachineorfuelcontai

Pagina 12 - SECTION8: TROUBLESHOOTING

SECTION2: ASSEMBLINGYOURLOGSPLITTERUnpackingfromCrate• Pry top, sides, and ends off the crate. Set panelsaside to avoid tire puncture or personal inju

Pagina 13 - HydraulicTroubleshooting

• Disconnect the log cradle from the beam on theside of the control valve. See Figure 4.Lock NutWasherHex BoltLog CradleFigure 4Lift and slide the cyl

Pagina 14 - For Taillight

SECTION3: KNOWYOURLOGSPLITTERCompare the illustration in Figure 7 below with the controls on your log splitter, and get familiar with its featuresbefo

Pagina 15 - ModelSeries550through570

SECTION4: OPERATINGYOURLOGSPLITTERWARNING: Read, understand, and follow allinstructions and warnings on the machine andin this manual before operating

Pagina 16

• Tolockthebeamintheverticalposition,pulloutontheverticalbeamlockandrotateittosecurethebeam.SeeFigure7.• Standinfrontoftheunittooperatethecontrolhandl